Osha Solar Roof Requirements

Construction workers involved in the installation of solar panels exposed to fall distances of 6 feet or more must be protected from falls by using one of the following methods.

Osha solar roof requirements.

Install warning lines no closer than 5 feet inside the roof edges and at a height of 34 to 45 inches. Occupational safety and health act requires employers to comply with safety and health standards promulgated by osha or by a state with an osha approved state plan. Related to installing solar panels. When contractors are hired to install solar panels on roofs with unprotected sides and edges more than six feet above a lower level they have three options.

Published in july 2019. Place warning lines and headers around the entire roof perimeter. A california based electrical contractor was working on a rooftop solar installation and assumed its workers were expected to comply with osha fall protection standards for roofers instead of the more stringent. Court of appeals for the ninth circuit resulted in a significant implications for safety standards for contractors performing roofing work.

What can contractors take away from the osha enforcement standard and the decision in bergelectric corp. Osha regulations for commercial roof inspections the occupational safety and health administration has set new guidelines for inspecting commercial roofs. If you run a solar installation company these are important to be aware of because it is your responsibility to ensure a safe workplace. Lay headers sheets of roofing or other materials no closer than 5 feet inside the edges of the roof and parallel to the roofline.

Osha has different fall protection requirements for construction installation of solar panels and general industry maintenance. Solar panel installation is not roofing work. A june decision by the u s. In addition the act s section 5 a 1 the general duty clause requires employers to provide their workers with a workplace free from recognized hazards likely to cause death.

The court determined that rooftop solar panel installation is not roofing work under osha regulations. If you choose to walk on a roof without these you will be out of compliance with osha regulations and subject to fines. For electrical contractors involved in solar roof installations who think that the same occupational safety and health administration osha safety requirements apply to their workers that apply to roofers a recent court ruling may come as a surprise.